Hydraulic Valve, CBEH-LJN; SUN HYDRAULICS; CAT TB 120/180;
Promulgator
：admin Time：2023-10-20
1 Grease Pump, p/n 1PLA66DG097.0425R; SPM for model MTU-4000 S-83 Engine
2 Hydraulic Valve Body, IAY; SUN HYDRAULICS for MTU-4000 S-81 Engine
3 Industrial Control Console, p/n 104241 for MC-60 Blender made by C.A.T.GmbH
4 Industrial Control Console, p/n 104240 for MC-60 Blender made by C.A.T.GmbH
5 Retaining Hex Bolt, p/n P18294; SPM (for model TWS-2000 Pump Valve); Material: steel
6 Body, p/n 210302-301 for model TWS-600S Pump
7 Liner, p/n 551.030 for model TWS-600S Pump; Material- Bronze
1 Valve, 70-00-045-0505; PBHB-LAN; SUN HYDRAULICS; for CAT TB-120/180; Т-17А
2 Valve, 70-00-045-0507; RPEC-LNN; SUN HYDRAULICS; for CAT TB-120/180; Т-10А
3 Hydraulic Valve, CBEH-LJN; SUN HYDRAULICS; CAT TB 120/180; 12 mm, 210 Bar, Steel
4 Hydraulic Valve, CXID-XCN; SUN HYDRAULICS; for CAT TB-120/180
5 Hydraulic Valve, DKFS-XHN; SUN HYDRAULICS; for CAT TB-180
6 Hydraulic Valve, FXDA-LIN; SUN HYDRAULICS; 25 mm, from 15 to 210 Atm, Steel
7 Hydraulic Valve, LOJD-8DN; SUN HYDRAULICS; for CAT TB-180; 1-1/2", 400 Bar
8 Reducing Valve, PBFB-LAN; SUN HYDRAULICS
9 Hydraulic Valve, PPDB-OEN; SUN HYDRAULICS
10 Valve Body; 70-00-045-0496; T-3A G1/2 CAV; SUN HYDRAULICS; for CAT TB-120/180
11 Valve Body; BAV/S; SUN HYDRAULICS
12 Valve Body; BCW/S; SUN HYDRAULICS; for CAT TB-120/180
13 Valve Body; HEW/S; SUN HYDRAULICS; for CAT TB-120/180
14 Hydraulic Valve Body; IAW; SUN HYDRAULICS
1 "MOTOR, "" ABB "", 37 KW
TYPE : M2QA 200 L2 B
PROD. CODE : 3GQA201502-ADA.002
IMB3 ( FOOT MOUNTING )
POWER : 37 KW
VOLTAGE : 400 VAC/D
FREQ. : 50 Hz
FULL SPEED : 2955 RPM
FULL LOAD : 64.36 A
INSULANCE CLASS : F
PROTECTION : IP55
TEMP. AMBIENT : 40oC
SERVICE FACTOR : 0.9
BEARING DE/NDE : 6312ZZ/C3, 6212ZZ/C3
STANDART IEC 60034-1
MERK : "" ABB """
2 "MOTOR, FRAME 132S IMB3, 11.0KW, 3000RPM MERK SIEMENS,
FRAME 132S, FOOT MOUNTED IMB3, 2950 RPM, 2 POLE,
11.0 KW, 380 VOLT, 50 HZ"
3 "MOTOR, FRAME 160M IMB35, 5.5KW, 750RPM MERK SIEMENS,
FRAME 160M, FOOT FLANGE MOUNTED IMB35, 730 RPM,
8 POLE, 5.5 KW, 380 VOLT, 50 HZ"
4 "MOTOR, FRAME 160L IMB5, 15.0KW, 1000RPM MERK SIEMENS,
FRAME 160L, FLANGE MOUNTED IMB5, 975 RPM, 6 POLE,
15.0 KW, 380 VOLT, 50 HZ"
5 "MOTOR, FRAME 160M FLANGE MOUNTED, 15.0KW, 3000RPM,
TYPE MG160MD2-42FF300-H3 MERK GRUNDFOSS, FRAME 160M,
FLANGE MOUNTED, 3000 RPM, 2 POLE, 15.0 KW, 380 VOLT, 50 HZ"
6 "MOTOR, FRAME 160ML IMB35, 10.0KW, 3000RPM MERK ABB,
FRAME 160ML, FOOT FLANGE MOUNTED IMB35, 2916 RPM,
2 POLE, 10.0 KW, 380 VOLT, 50 HZ
The correct power is 11KW"
7 "MOTOR, FRAME 180ML IMV1, 18.5KW
1500RPM, MERK: ABB, FRAME 180ML
FLANGE MOUNTED IMV1/IM3011
1477RPM, 4POLE, 18.5KW, 380VOLT, 50HZ
M2QA"
8 "MOTOR, FRAME 315M IMB5, 132.0KW, 1500RPM MERK SIEMENS,
FRAME 315M, FLANGE MOUNTED IMB5, 1490 RPM, 4 POLE,
132.0 KW, 380 VOLT, 50 HZ"
9 "MOTOR, FRAME 315L IMB3, 240.0KW, 3000RPM,
TYPE 1LG6 318-2MB90-Z MERK SIEMENS, FRAME 315L,
FOOT MOUNTED IMB3, 2986 RPM, 2 POLE, 240.0 KW,
380 VOLT, 50 HZ MOTOR WITH DOUBLE SHAFT DE NDE"
10 "MOTOR, FRAME 280S/M-02, 132.0KW, 2975RPM
MERK WEG W22 PREMIUM CC029A, FRAME 280S/M-02, 2975 RPM,
2 POLE, 132.0 KW, 380 VOLT, 50 HZ"
11 "MOTOR, FRAME 250SM IMB35, 55.0KW, 1500RPM MERK ABB,
FRAME 250SM, FOOT FLANGE MOUNTED IMB35, 1476 RPM,
4 POLE, 55.0 KW, 380 VOLT, 50 HZ
M2QA"
12 "MOTOR, AC; 3PH; 355KW; 380V; 1487RPM; ABB
FRAME: M3BP 355 SMC4 B3(FOOT MOUNTING)
AMPERE: 616, Hz: 50Hz, COS Q: 0.86
PRODUK CODE: 3GBP 352230..G
C/W.
a.CERTIFICATE OF ORIGINAL
b.TEST REPORT DARI MOTOR TERSEBUT"
13 "MOTOR, AC: 3 PHASE
KW: 160KW
TYPE: M3BP 355 SMA6 IMB3/IM 1001 (FOOT MOUNTING)
VOLTS: 380V
RPM: 992RPM
FRAME: 315 S/M-02
AMPERE: 305A
FREQ: 50Hz
PRODUK CODE: 3GGP353210-ADG037452
INSUL.. CLASS :F
IP: 55
BEARING DS: NU 322 EC/C3
BEARING NDS: 6236/C3
C/W:
-CERTIFICATE OF ORIGINAL
-TEST REPORT
MERK: ABB"
1 Controller SCM2 2510.0220 Hasler
2 Communication module 1660.9500 Hasler
3 Communication module 2510.8860 Hasler
4 Expansion Board SCM 2510.8661 Hasler
5 Noise control device Sound1 Hasler
AWEF004D06 Pump sensor
1 butterfly valve seal M&S Armaturen GmbH SV04/TYP98 ART.-NR 57680-0500100 DIN 50 VMQ
2 butterfly valve seal M&S Armaturen GmbH SV04/TYP98 ART.-NR 57680-0650100 DIN 65 VMQ
3 M&S Armaturen GmbH WASHING CYLINDER SEAL ART.-NR 61900 - 0500200 DIN 50
4 M&S Armaturen GmbH WASHING CYLINDER SEAL ART.-NR 61900 - 0650200 DIN 65
5 WASHING CYLINDER M&S Armaturen GmbH ART.-NR 61700 - 0500 DIN 50
6 WASHING CYLINDRE M&S Armaturen GmbH ART.-NR 61700 - 06500 DIN 65
7 butterfly valve seal M&S Armaturen GmbH SV04/TYP98 ART.-NR56040-0500100 DIN 50 VMQ
8 butterfly valve seal M&S Armaturen GmbH SV04/TYP98 ART.-NR56040-0650100 DIN 50 VMQ
PALL Ultipleat High flow filter element HFU660UY045J 4,5 microns
1 Belt 6N6651 Caterpillar
2 Belt 6N7135 Caterpillar
3 Belt 8N6717 Caterpillar
4 Alternator Belt 4N2531 Caterpillar
5 Air Filter 8N2556 Caterpillar
6 Air filter 8N6309 Caterpillar
7 Air filter P532509 Donaldson
8 Air filter P532510 Donaldson
9 Oil filter P551808 Donaldson
10 Oil filter DS-1R-0726 Caterpillar
11 Fuel filter P551010 Donaldson
12 Fuel filter P551311 Donaldson
13 Fuel filter P551316 Donaldson
14 Fine fuel filter DS-1R-0756 Caterpillar
1 Hydraulic Pump M2JA132 M6B B35 A37-F-R-01-H-S-K
2 Wash pipe seal 127х95
3 Mud hose ø4"х35 Мра, connection type FIG 1003, 23 meters, quick coupling connection for connecting top driver with stand pipes on Chinese drilling rig
4 Centre pipe 95х250
5 Winch brake disk JC-70 106.06.25.00
6 Winch friction coil JC-70 106.25.10.00
7 Drive roller chain 10 meters 32S-2
8 Drive roller chain 10 meters 32S-4
9 Drive roller chain 10 meters 24S-6
10 Drilling sleeve ø4 "x35 MPa FIG thread type 1003.19 meters, quick-detachable thread-nut for Chinese installations
11 Outer gear bushing 106.16.30.05
12 Outer gear bushing 106.16.36.01
13 Outer gear bushing 106.16.37.04
14 Outer gear bushing 106.16.37.03
15 Outer gear bushing 106.16.36.02
16 Outer gear bushing 106.16.36.05
17 Outer gear bushing 106.16.36.09
18 Rotor transmission sprocket Z-20T=50.08 106.16.10.01
19 Fixing bolt for brake disk 106.02.24.05
20 Centrifugal pump 32SB180-100 32SB180J-2.2KW
21 Brake Oil Pump Rexroth D-72150 A10V-Horb
22 10-meter chain 24S-3
23 Cylinder sleeve Ø 130 mm АН000003031200
24 Cylinder sleeve Ø 140 mm АН000003031300
25 Cylinder sleeve Ø 150 mm АН000003031400
26 Cylinder sleeve Ø 160 mm АН000003031500
27 Cylinder sleeve Ø 170 mm АН000003031600
28 Cylinder sleeve Ø 180 mm АН000003031700
29 Polyurethane piston Ø 130 mm АН0000040300
30 Polyurethane piston Ø 140 mm АН0000040500
31 Polyurethane piston Ø 150 mm АН0000040600
32 Polyurethane piston Ø 160 mm АН0000040700
33 Polyurethane piston Ø 170 mm АН0000040800
34 Polyurethane piston Ø 180 mm АН0000040900
35 Valve body 107.11.140.00
36 Valve seat 107.11.140.04
37 Fluid end assembly F-1600/F-1300
38 Polyurethane valve rubber (plate)
39 Valve holder (upper) АН 1001010510
40 Valve holder (lower) АН130101050500
41 Half-rod seal F-1600/F-1300
42 Rod cooling pump assembly with electric motor, horizontal type F-1600
43 Spray pump with electric motor, vertical type F-1600
44 Air bag diaphragm KW-75 AH130101050500
45 V-belt А3708 L=9000 F-1300 HGT-2819
46 Cardan shaft crosspiece SWC 180 (21KN)
47 Auxiliary brake of the main drum WCB-324 JC 060000
48 Combined transfer gear case for the Power system DL050000
49 Coupling cylinder 20 CB 500 (pump drive F-800) BZ070300
50
51 Cylinder block (flat ring plate) АТD330 H Airbag АТD330 H
52 Drive chain 44.45mm 10 meters each 44.45mm 10 meters each
53 Winch brake disk JC-70 JC28/11-06-12-00
54 Drilling sleeve ø4 "x35 MPa FIG thread type 1003. 17,5 meters, quick-detachable thread-nut (ХJ -750,ZJ -30T) for Chinese installations
55 Crosspiece for universal joint shaft
56 Universal joint shaft SWC-180ВН-1370+60 21КN JB/T5513-2006
57 Universal joint shaft SWC-180ВН-1355+60 21КN JB/T5513-2006
58 Universal joint shaft SWC-180ВН-1755+60 21КN JB/T5513-2006
59 Universal joint shaft SWC-180ВН-1600+60 21КN JB/T5513-2006
60 Universal joint shaft SWC-180ВН-18750+60 21КN JB/T5513-2006
61 Auxiliary brake ETON (WСВ324 water cooler brake)
62 Oil filter 02250054-605
63 Water separation filter 02250100-753
64 Air filter 12Р/N 049301
65 Oil radiator
66 Belt 8N-6717
67 Chain wheel (sprocket) Z=24 Р=50,8 ZP 000001
68 Main bearing 5692/800 ZP 000004
69 Support bearing NU 2330 ZP 000011
70 Auxiliary bearing 591/800 ZP 000028
71 Mud pipe assembly 104.05.30.00
72 Feeding tube 104.05.30.03
73 Upper bushing АD4500010506
74 Spring O-ring (top) PD220x260x18 HG4-692-67
75 Spring O-ring (bottom) PD250x290x18 HG4-692-67
76 Bottom bearing 240х360х56 (32148) SL 000039
77 Main bearing 270х550х130 (19954ЕQ) SL 000036
78 Top bearing 200х310х70 (2007140) SL 000031
79 Mud pipe collar
80 Feed tube O-ring (top) 104.05.30.08
81 Feed tube O-ring (bottom) 104.05.30.08-1
82 Axial piston pump JGBOY-BL
83 Gear oil pump YB040013
1 Belt 6N6651 Caterpillar
2 Belt 6N7135 Caterpillar
3 Belt 8N6717 Caterpillar
4 Alternator Belt 4N2531 Caterpillar
5 Air Filter 8N2556 Caterpillar
6 Air filter 8N6309 Caterpillar
7 Air filter P532509 Donaldson
8 Air filter P532510 Donaldson
9 Oil filter P551808 Donaldson
10 Oil filter DS-1R-0726 Caterpillar
11 Fuel filter P551010 Donaldson
12 Fuel filter P551311 Donaldson
13 Fuel filter P551316 Donaldson
14 Fine fuel filter DS-1R-0756 Caterpillar
1 Fuel Filter, p/n СА1R0755 CATERPILLAR C-32 Engine
2 Oil Filter Element, p/n 23530573 DETROIT DIESEL SERIES 60 Engine
3 Filter Element, p/n 29510910 ALLISON (CATERPILLAR C-15 Engine)
4 Air Filter, p/n 8N6309 CATERPILLAR 3406E Engine
5 Air Filter, p/n 8N2556
6 Oil Filter, p/n 2752604 CATERPILLAR 3406E Engine. Material: Felt, Steel
7 Filter Element, p/n 8591840001 MTU, Material: Paper
8 Oil Filter, p/n 29548988 ALLISON (for SPM TWS-600S Pump). Material: SYNTHETIC FIBER
Stober E-pinion gear Z 12 M 1,25 18 E6/7, part no. 89745 QTY8
Main gear wheel Stober Z153 M1,25 40 E7, article no. 89800 QTY3
1 Valve REXROTH P-054350-00003
2 Valve REXROTH P-055119-00000
3 Valve REXROTH P-055161-00000
4 Valve REXROTH P-055556-00003
5 Valve REXROTH P-055676-00000
6 Valve REXROTH P-059331-00000
7 Valve REXROTH P-059335-00000
8 Valve REXROTH P-063985-00000
9 Valve REXROTH P-431003350
10 Valve REXROTH P-50967-00001
11 Valve REXROTH P-50973-00003
12 Valve REXROTH P-60921-00003
13 Valve REXROTH R431003806
14 Valve P50494-00004
15 Valve REXROTH P-065263-00000
16 Pneumatic cylinder REXROTH P-055557-00003
17 Pneumatic cylinder REXROTH ТМ-831000-00040
18 Valve REXROTH R431000671
19 Valve REXROTH R431005619
20 Valve Rexroth Р-026720-00002
21 Pressure regulator R431002837
22 Valve P50975-00002
Intrinsically safe barrier 12-28V EM-DR1-IS-5-RTB-28V/V BEIsensors
Intrinsically safe barrier NPEXA-C311P part. 1400003598
MTL7760AC IS Barrier
Power supply ABL8 1-phase input AC100-240V/DC120-250 output DC24V 1.2A
Varistor 2414620 Caterpillar C15
Double solenoid 01 Ex01 049A 2424 (Schienle Magnettechnik)
Uninterruptible power supply TG1000;220V;50Hz
Micropulse power supply 644-6935
Communication module CM 1241 RS422/485
Profibus connector (conn-profibus dp w/programmic port)
IGBT module ACS880 1400A/1700V PRIMEPACK 3AXD50000024022 ABB
IGBT module BGAD-21C/500A,1700V,EP+ W/ COVER SP 3AXD50000158898 ABB
Module RDCU-12C 3AUA0000036521 ABB
Module SCHL191107L1 2-channel for enconder 0636741 Bentec
Analog input module IC695ALG508, GE Fanuc
Intrinsically safe barrier module MK-493 4DI/4DO
Blocking module MB1
Diode module 0000-9641-88 POWEREX
Proportional Valve Control Module SD6301D20-AA #2 WANDFLUH
Proportional valve control module SD7201D20-AA WANDFLUH
Woodward SPM-D11 diesel generator set synchronization panel
Interface board AINT-02C ACS800 No. 68257867 (ABB)
Inverter power board ZPOW-7B1C No. 3AXD50000017375 ABB
DriveWindow 2.x software with USB connection 3AUA0000040000 ABB
Potentiometer DP120-47Lt/104579 10kOhm W.Gessman
Manual push-button starter SQD-2510-MC03 Derrick FLC-503
Manual push-button starter SQD-2510-MC03 Derrick FLC-503
Resistor CAH 150 CH 411 3R3 +-10% F2 ZH 1153133411, Danotherm
Servo drive AIR SC 3005N-230N 5Nm
Servo drive SF24A-SR Belimo
Connector for connection to PROFIBUS SIMATIC DP 6ES7 972-0DA60-0XA0 Siemens
Proportional amplifier EV 22 K5-12/24 HAWE, Hydraulik
Soft starter 15A CSXi-007-V4-C1 AuCom
Soft starter MST-M53-12-S Bitek
Electronic cable 29537703 Allison
Encoder CONTROL REGULATOR (0001-0870-32) (to TDS)
